Energy and exergy analysis as tools for optimization of hydrogen production by glycerol autothermal reforming
Identifieur interne : 000279 ( Main/Curation ); précédent : 000278; suivant : 000280Energy and exergy analysis as tools for optimization of hydrogen production by glycerol autothermal reforming
Auteurs : Noureddine Hajjaji [Tunisie] ; Ines Baccar [Tunisie] ; Marie-Noëlle Pons [France]Source :
- Renewable Energy [ 0960-1481 ] ; 2014-11.
Abstract
In this work, various assessment tools were comprehensively applied to investigate hydrogen production via glycerol autothermal reforming. These tools are used to study the chemical reactions, design and simulate the entire hydrogen production process, investigate the energetic and exergetic performances of the processes and perform parametric analyses (using intuitive and design of experiment-based methods). Investigating the chemical reactions of autothermal reforming (ATR) of glycerol reveals that the optimal conditions, based on maximizing the hydrogen production, minimizing the methane and carbon monoxide contents and eliminating coke formation at thermoneutral conditions, can be achieved at a water glycerol feed ratio (WGFR), reforming temperature (T) and oxygen-glycerol feed ratio (OGFR) of 9, 900 K and 0.35, respectively. The energetic study of the resulting process indicates that approximately two-thirds of the energy fed to the process is recovered in the useful product (H-2) and that the remaining incoming process energy is exhausted in the off-gas. The exergetic investigation reveals that the exergetic efficiency of the ATR process is 57% and that 152 kJ are destroyed to generate 1 mol of hydrogen. The process operating conditions recommended by the chemical reaction investigation suffers from low performance because energetic and exergetic efficiencies are comparatively lower than values previously reported in literature for other reformates. The parametric investigation indicates that more accurate conditions are needed to convert glycerol hydrogen. These conditions ensure the lowest consumption of energy to generate a given amount of hydrogen. This paper recommends WGFR = 5.5, T = 900 K and OGFR = 0.96 as the optimum conditions for the entire glycerol-to-hydrogen process. For this configuration, the thermal and exergetic efficiencies are 78.7% and 67.8%, respectively.
Url:
DOI: 10.1016/j.renene.2014.05.056
Links toward previous steps (curation, corpus...)
- to stream Hal, to step Corpus: Pour aller vers cette notice dans l'étape Curation :000423
- to stream Hal, to step Curation: Pour aller vers cette notice dans l'étape Curation :000423
- to stream Hal, to step Checkpoint: Pour aller vers cette notice dans l'étape Curation :000257
- to stream Main, to step Merge: Pour aller vers cette notice dans l'étape Curation :000281
Links to Exploration step
Hal:hal-01274047Le document en format XML
<record><TEI><teiHeader><fileDesc><titleStmt><title xml:lang="en">Energy and exergy analysis as tools for optimization of hydrogen production by glycerol autothermal reforming</title>
<author><name sortKey="Hajjaji, Noureddine" sort="Hajjaji, Noureddine" uniqKey="Hajjaji N" first="Noureddine" last="Hajjaji">Noureddine Hajjaji</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-219014" status="INCOMING"><orgName>Unite Rech Catalyse & Mat Environm & Proc URCMEP</orgName>
<orgName type="acronym">URMCEP</orgName>
<desc><address><addrLine>Unite Rech Catalyse & Mat Environm & Proc URCMEP Ecole Nationale d'Ingénieurs de Gabès 6029 GABES Tunisie</addrLine>
<country key="TN"></country>
</address>
</desc>
<listRelation><relation active="#struct-301052" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-301052" type="direct"><org type="institution" xml:id="struct-301052" status="VALID"><orgName>Ecole Nationale d'Ingénieurs de Gabès</orgName>
<desc><address><country key="FR"></country>
</address>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>Tunisie</country>
</affiliation>
</author>
<author><name sortKey="Baccar, Ines" sort="Baccar, Ines" uniqKey="Baccar I" first="Ines" last="Baccar">Ines Baccar</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-219014" status="INCOMING"><orgName>Unite Rech Catalyse & Mat Environm & Proc URCMEP</orgName>
<orgName type="acronym">URMCEP</orgName>
<desc><address><addrLine>Unite Rech Catalyse & Mat Environm & Proc URCMEP Ecole Nationale d'Ingénieurs de Gabès 6029 GABES Tunisie</addrLine>
<country key="TN"></country>
</address>
</desc>
<listRelation><relation active="#struct-301052" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-301052" type="direct"><org type="institution" xml:id="struct-301052" status="VALID"><orgName>Ecole Nationale d'Ingénieurs de Gabès</orgName>
<desc><address><country key="FR"></country>
</address>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>Tunisie</country>
</affiliation>
</author>
<author><name sortKey="Pons, Marie Noelle" sort="Pons, Marie Noelle" uniqKey="Pons M" first="Marie-Noëlle" last="Pons">Marie-Noëlle Pons</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-211875" status="VALID"><idno type="IdRef">153068876</idno>
<idno type="RNSR">201320573K</idno>
<idno type="IdUnivLorraine">[UL]RQC--</idno>
<orgName>Laboratoire Réactions et Génie des Procédés</orgName>
<orgName type="acronym">LRGP</orgName>
<date type="start">2013-01-01</date>
<desc><address><addrLine>Université de Lorraine - ENSIC, 1 rue de Grandville BP 20451, 54001 Nancy Cedex</addrLine>
<country key="FR"></country>
</address>
<ref type="url">http://lrgp.univ-lorraine.fr/</ref>
</desc>
<listRelation><relation active="#struct-413289" type="direct"></relation>
<relation name="UMR7274" active="#struct-441569" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-413289" type="direct"><org type="institution" xml:id="struct-413289" status="VALID"><idno type="IdRef">157040569</idno>
<idno type="IdUnivLorraine">[UL]100--</idno>
<orgName>Université de Lorraine</orgName>
<orgName type="acronym">UL</orgName>
<date type="start">2012-01-01</date>
<desc><address><addrLine>34 cours Léopold - CS 25233 - 54052 Nancy cedex</addrLine>
<country key="FR"></country>
</address>
<ref type="url">http://www.univ-lorraine.fr/</ref>
</desc>
</org>
</tutelle>
<tutelle name="UMR7274" active="#struct-441569" type="direct"><org type="institution" xml:id="struct-441569" status="VALID"><idno type="ISNI">0000000122597504</idno>
<idno type="IdRef">02636817X</idno>
<orgName>Centre National de la Recherche Scientifique</orgName>
<orgName type="acronym">CNRS</orgName>
<date type="start">1939-10-19</date>
<desc><address><country key="FR"></country>
</address>
<ref type="url">http://www.cnrs.fr/</ref>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>France</country>
<placeName><settlement type="city">Nancy</settlement>
<settlement type="city">Metz</settlement>
<region type="region" nuts="2">Grand Est</region>
<region type="old region" nuts="2">Lorraine (région)</region>
</placeName>
<orgName type="university">Université de Lorraine</orgName>
<placeName><settlement type="city">Nancy</settlement>
<region type="region" nuts="2">Grand Est</region>
<region type="region" nuts="2">Lorraine (région)</region>
</placeName>
<orgName type="laboratoire" n="5">Laboratoire réactions et génie des procédés</orgName>
<orgName type="university">Université de Lorraine</orgName>
<orgName type="institution">Centre national de la recherche scientifique</orgName>
</affiliation>
</author>
</titleStmt>
<publicationStmt><idno type="wicri:source">HAL</idno>
<idno type="RBID">Hal:hal-01274047</idno>
<idno type="halId">hal-01274047</idno>
<idno type="halUri">https://hal.univ-lorraine.fr/hal-01274047</idno>
<idno type="url">https://hal.univ-lorraine.fr/hal-01274047</idno>
<idno type="doi">10.1016/j.renene.2014.05.056</idno>
<date when="2014-11">2014-11</date>
<idno type="wicri:Area/Hal/Corpus">000423</idno>
<idno type="wicri:Area/Hal/Curation">000423</idno>
<idno type="wicri:Area/Hal/Checkpoint">000257</idno>
<idno type="wicri:explorRef" wicri:stream="Hal" wicri:step="Checkpoint">000257</idno>
<idno type="wicri:doubleKey">0960-1481:2014:Hajjaji N:energy:and:exergy</idno>
<idno type="wicri:Area/Main/Merge">000281</idno>
<idno type="wicri:Area/Main/Curation">000279</idno>
</publicationStmt>
<sourceDesc><biblStruct><analytic><title xml:lang="en">Energy and exergy analysis as tools for optimization of hydrogen production by glycerol autothermal reforming</title>
<author><name sortKey="Hajjaji, Noureddine" sort="Hajjaji, Noureddine" uniqKey="Hajjaji N" first="Noureddine" last="Hajjaji">Noureddine Hajjaji</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-219014" status="INCOMING"><orgName>Unite Rech Catalyse & Mat Environm & Proc URCMEP</orgName>
<orgName type="acronym">URMCEP</orgName>
<desc><address><addrLine>Unite Rech Catalyse & Mat Environm & Proc URCMEP Ecole Nationale d'Ingénieurs de Gabès 6029 GABES Tunisie</addrLine>
<country key="TN"></country>
</address>
</desc>
<listRelation><relation active="#struct-301052" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-301052" type="direct"><org type="institution" xml:id="struct-301052" status="VALID"><orgName>Ecole Nationale d'Ingénieurs de Gabès</orgName>
<desc><address><country key="FR"></country>
</address>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>Tunisie</country>
</affiliation>
</author>
<author><name sortKey="Baccar, Ines" sort="Baccar, Ines" uniqKey="Baccar I" first="Ines" last="Baccar">Ines Baccar</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-219014" status="INCOMING"><orgName>Unite Rech Catalyse & Mat Environm & Proc URCMEP</orgName>
<orgName type="acronym">URMCEP</orgName>
<desc><address><addrLine>Unite Rech Catalyse & Mat Environm & Proc URCMEP Ecole Nationale d'Ingénieurs de Gabès 6029 GABES Tunisie</addrLine>
<country key="TN"></country>
</address>
</desc>
<listRelation><relation active="#struct-301052" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-301052" type="direct"><org type="institution" xml:id="struct-301052" status="VALID"><orgName>Ecole Nationale d'Ingénieurs de Gabès</orgName>
<desc><address><country key="FR"></country>
</address>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>Tunisie</country>
</affiliation>
</author>
<author><name sortKey="Pons, Marie Noelle" sort="Pons, Marie Noelle" uniqKey="Pons M" first="Marie-Noëlle" last="Pons">Marie-Noëlle Pons</name>
<affiliation wicri:level="1"><hal:affiliation type="laboratory" xml:id="struct-211875" status="VALID"><idno type="IdRef">153068876</idno>
<idno type="RNSR">201320573K</idno>
<idno type="IdUnivLorraine">[UL]RQC--</idno>
<orgName>Laboratoire Réactions et Génie des Procédés</orgName>
<orgName type="acronym">LRGP</orgName>
<date type="start">2013-01-01</date>
<desc><address><addrLine>Université de Lorraine - ENSIC, 1 rue de Grandville BP 20451, 54001 Nancy Cedex</addrLine>
<country key="FR"></country>
</address>
<ref type="url">http://lrgp.univ-lorraine.fr/</ref>
</desc>
<listRelation><relation active="#struct-413289" type="direct"></relation>
<relation name="UMR7274" active="#struct-441569" type="direct"></relation>
</listRelation>
<tutelles><tutelle active="#struct-413289" type="direct"><org type="institution" xml:id="struct-413289" status="VALID"><idno type="IdRef">157040569</idno>
<idno type="IdUnivLorraine">[UL]100--</idno>
<orgName>Université de Lorraine</orgName>
<orgName type="acronym">UL</orgName>
<date type="start">2012-01-01</date>
<desc><address><addrLine>34 cours Léopold - CS 25233 - 54052 Nancy cedex</addrLine>
<country key="FR"></country>
</address>
<ref type="url">http://www.univ-lorraine.fr/</ref>
</desc>
</org>
</tutelle>
<tutelle name="UMR7274" active="#struct-441569" type="direct"><org type="institution" xml:id="struct-441569" status="VALID"><idno type="ISNI">0000000122597504</idno>
<idno type="IdRef">02636817X</idno>
<orgName>Centre National de la Recherche Scientifique</orgName>
<orgName type="acronym">CNRS</orgName>
<date type="start">1939-10-19</date>
<desc><address><country key="FR"></country>
</address>
<ref type="url">http://www.cnrs.fr/</ref>
</desc>
</org>
</tutelle>
</tutelles>
</hal:affiliation>
<country>France</country>
<placeName><settlement type="city">Nancy</settlement>
<settlement type="city">Metz</settlement>
<region type="region" nuts="2">Grand Est</region>
<region type="old region" nuts="2">Lorraine (région)</region>
</placeName>
<orgName type="university">Université de Lorraine</orgName>
<placeName><settlement type="city">Nancy</settlement>
<region type="region" nuts="2">Grand Est</region>
<region type="region" nuts="2">Lorraine (région)</region>
</placeName>
<orgName type="laboratoire" n="5">Laboratoire réactions et génie des procédés</orgName>
<orgName type="university">Université de Lorraine</orgName>
<orgName type="institution">Centre national de la recherche scientifique</orgName>
</affiliation>
</author>
</analytic>
<idno type="DOI">10.1016/j.renene.2014.05.056</idno>
<series><title level="j">Renewable Energy</title>
<idno type="ISSN">0960-1481</idno>
<imprint><date type="datePub">2014-11</date>
</imprint>
</series>
</biblStruct>
</sourceDesc>
</fileDesc>
<profileDesc><textClass></textClass>
</profileDesc>
</teiHeader>
<front><div type="abstract" xml:lang="en">In this work, various assessment tools were comprehensively applied to investigate hydrogen production via glycerol autothermal reforming. These tools are used to study the chemical reactions, design and simulate the entire hydrogen production process, investigate the energetic and exergetic performances of the processes and perform parametric analyses (using intuitive and design of experiment-based methods). Investigating the chemical reactions of autothermal reforming (ATR) of glycerol reveals that the optimal conditions, based on maximizing the hydrogen production, minimizing the methane and carbon monoxide contents and eliminating coke formation at thermoneutral conditions, can be achieved at a water glycerol feed ratio (WGFR), reforming temperature (T) and oxygen-glycerol feed ratio (OGFR) of 9, 900 K and 0.35, respectively. The energetic study of the resulting process indicates that approximately two-thirds of the energy fed to the process is recovered in the useful product (H-2) and that the remaining incoming process energy is exhausted in the off-gas. The exergetic investigation reveals that the exergetic efficiency of the ATR process is 57% and that 152 kJ are destroyed to generate 1 mol of hydrogen. The process operating conditions recommended by the chemical reaction investigation suffers from low performance because energetic and exergetic efficiencies are comparatively lower than values previously reported in literature for other reformates. The parametric investigation indicates that more accurate conditions are needed to convert glycerol hydrogen. These conditions ensure the lowest consumption of energy to generate a given amount of hydrogen. This paper recommends WGFR = 5.5, T = 900 K and OGFR = 0.96 as the optimum conditions for the entire glycerol-to-hydrogen process. For this configuration, the thermal and exergetic efficiencies are 78.7% and 67.8%, respectively.</div>
</front>
</TEI>
</record>
Pour manipuler ce document sous Unix (Dilib)
EXPLOR_STEP=$WICRI_ROOT/Wicri/Lorraine/explor/LrgpV1/Data/Main/Curation
HfdSelect -h $EXPLOR_STEP/biblio.hfd -nk 000279 | SxmlIndent | more
Ou
HfdSelect -h $EXPLOR_AREA/Data/Main/Curation/biblio.hfd -nk 000279 | SxmlIndent | more
Pour mettre un lien sur cette page dans le réseau Wicri
{{Explor lien |wiki= Wicri/Lorraine |area= LrgpV1 |flux= Main |étape= Curation |type= RBID |clé= Hal:hal-01274047 |texte= Energy and exergy analysis as tools for optimization of hydrogen production by glycerol autothermal reforming }}
![]() | This area was generated with Dilib version V0.6.32. | ![]() |