NickelMaghrebV1, Main, Exploration, bibRecord, 000C66

Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath

Identifieur interne : 000C66 ( Main/Exploration ); précédent : 000C65; suivant : 000C67

Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath

Auteurs : M. Bouanani [Maroc] ; F. Cherkaoui [Maroc] ; R. Fratesi [Italie] ; G. Roventi [Italie] ; G. Barucca [Italie]

Source :

Journal of applied electrochemistry [ 0021-891X ] ; 1999.

RBID : Pascal:99-0360542

Descripteurs français

Pascal (Inist)
- Résistance corrosion, Dépôt par oxydoréduction, Alliage ternaire, Nickel Alliage, Zinc Alliage, Phosphore Alliage, Sulfate, Effet milieu, pH, Morphologie, Structure surface, Microscopie électronique balayage, Diffraction RX, Microscopie électronique transmission, Diffraction Bragg, Incidence rasante.

English descriptors

KwdEn :
- Bragg diffraction, Corrosion resistance, Electroless plating, Grazing incidence, Medium effect, Morphology, Nickel Alloys, Phosphorus Alloys, Scanning electron microscopy, Sulfates, Surface structure, Ternary alloy, Transmission electron microscopy, X ray diffraction, Zinc Alloys, pH.

Abstract

Electroless Ni-Zn-P alloy coatings were obtained on an iron substrate from a sulfate bath at various pH values. The effects of changes in bath pH on alloy composition, morphology, microstructure and corrosion resistance were studied. Scanning electron microscopy was performed to observe the morphological change of the deposits with bath pH. Coating crystallinity was investigated by grazing incidence asymmetric Bragg X-ray diffraction and transmission electron microscopy. A transition from an amorphous to polycrystalline structure was observed on increasing the bath alkalinity, and thus decreasing the phosphorus content of the alloys. A single crystalline phase corresponding to face-centred-cubic nickel was identified in the alloys obtained from a strong alkaline solution. An increase in zinc percentage up to 23% in the deposits does not change the f.c.c. nickel crystalline structure. Corrosion potential and polarization resistance measurements indicated that the corrosion resistance of electroless Ni-Zn-P alloys depends strongly on the microstructure and chemical composition. The deposits obtained at pH 9.0-9.5 and with 11.4-12.5% zinc and 11.8-11.2% phosphorous exhibited the best corrosion resistance.

Affiliations:

Links toward previous steps (curation, corpus...)

to stream PascalFrancis, to step Corpus: 000453
to stream PascalFrancis, to step Curation: 000614
to stream PascalFrancis, to step Checkpoint: 000457
to stream Main, to step Merge: 000D06
to stream Main, to step Curation: 000C66

Le document en format XML

<record><TEI><teiHeader><fileDesc><titleStmt><title xml:lang="en" level="a">Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath</title>
<author><name sortKey="Bouanani, M" sort="Bouanani, M" uniqKey="Bouanani M" first="M." last="Bouanani">M. Bouanani</name>
<affiliation wicri:level="3"><inist:fA14 i1="01"><s1>Laboratoire d'Electrochimie et de Chimie Analytique, Faculté des Sciences, Université Mohammed V. Avenue Ibn Battouta B.P. 1014</s1>
<s2>Rabat</s2>
<s3>MAR</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
</inist:fA14>
<country>Maroc</country>
<placeName><settlement type="city">Rabat</settlement>
<region nuts="2">Rabat-Salé-Kénitra</region>
</placeName>
</affiliation>
</author>
<author><name sortKey="Cherkaoui, F" sort="Cherkaoui, F" uniqKey="Cherkaoui F" first="F." last="Cherkaoui">F. Cherkaoui</name>
<affiliation wicri:level="3"><inist:fA14 i1="01"><s1>Laboratoire d'Electrochimie et de Chimie Analytique, Faculté des Sciences, Université Mohammed V. Avenue Ibn Battouta B.P. 1014</s1>
<s2>Rabat</s2>
<s3>MAR</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
</inist:fA14>
<country>Maroc</country>
<placeName><settlement type="city">Rabat</settlement>
<region nuts="2">Rabat-Salé-Kénitra</region>
</placeName>
</affiliation>
</author>
<author><name sortKey="Fratesi, R" sort="Fratesi, R" uniqKey="Fratesi R" first="R." last="Fratesi">R. Fratesi</name>
<affiliation wicri:level="1"><inist:fA14 i1="02"><s1>Dipartimento di Scienze dei Materiali e della Terra</s1>
<s2>Ancona</s2>
<s3>ITA</s3>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>Dipartimento di Scienze dei Materiali e della Terra</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Roventi, G" sort="Roventi, G" uniqKey="Roventi G" first="G." last="Roventi">G. Roventi</name>
<affiliation wicri:level="1"><inist:fA14 i1="02"><s1>Dipartimento di Scienze dei Materiali e della Terra</s1>
<s2>Ancona</s2>
<s3>ITA</s3>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>Dipartimento di Scienze dei Materiali e della Terra</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Barucca, G" sort="Barucca, G" uniqKey="Barucca G" first="G." last="Barucca">G. Barucca</name>
<affiliation wicri:level="1"><inist:fA14 i1="03"><s1>INFM Università degli Studi di Ancona, Via Brecce Bianche</s1>
<s2>60131, Ancona</s2>
<s3>ITA</s3>
<sZ>5 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>60131, Ancona</wicri:noRegion>
</affiliation>
</author>
</titleStmt>
<publicationStmt><idno type="wicri:source">INIST</idno>
<idno type="inist">99-0360542</idno>
<date when="1999">1999</date>
<idno type="stanalyst">PASCAL 99-0360542 INIST</idno>
<idno type="RBID">Pascal:99-0360542</idno>
<idno type="wicri:Area/PascalFrancis/Corpus">000453</idno>
<idno type="wicri:Area/PascalFrancis/Curation">000614</idno>
<idno type="wicri:Area/PascalFrancis/Checkpoint">000457</idno>
<idno type="wicri:explorRef" wicri:stream="PascalFrancis" wicri:step="Checkpoint">000457</idno>
<idno type="wicri:doubleKey">0021-891X:1999:Bouanani M:microstructural:characterization:and</idno>
<idno type="wicri:Area/Main/Merge">000D06</idno>
<idno type="wicri:Area/Main/Curation">000C66</idno>
<idno type="wicri:Area/Main/Exploration">000C66</idno>
</publicationStmt>
<sourceDesc><biblStruct><analytic><title xml:lang="en" level="a">Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath</title>
<author><name sortKey="Bouanani, M" sort="Bouanani, M" uniqKey="Bouanani M" first="M." last="Bouanani">M. Bouanani</name>
<affiliation wicri:level="3"><inist:fA14 i1="01"><s1>Laboratoire d'Electrochimie et de Chimie Analytique, Faculté des Sciences, Université Mohammed V. Avenue Ibn Battouta B.P. 1014</s1>
<s2>Rabat</s2>
<s3>MAR</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
</inist:fA14>
<country>Maroc</country>
<placeName><settlement type="city">Rabat</settlement>
<region nuts="2">Rabat-Salé-Kénitra</region>
</placeName>
</affiliation>
</author>
<author><name sortKey="Cherkaoui, F" sort="Cherkaoui, F" uniqKey="Cherkaoui F" first="F." last="Cherkaoui">F. Cherkaoui</name>
<affiliation wicri:level="3"><inist:fA14 i1="01"><s1>Laboratoire d'Electrochimie et de Chimie Analytique, Faculté des Sciences, Université Mohammed V. Avenue Ibn Battouta B.P. 1014</s1>
<s2>Rabat</s2>
<s3>MAR</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
</inist:fA14>
<country>Maroc</country>
<placeName><settlement type="city">Rabat</settlement>
<region nuts="2">Rabat-Salé-Kénitra</region>
</placeName>
</affiliation>
</author>
<author><name sortKey="Fratesi, R" sort="Fratesi, R" uniqKey="Fratesi R" first="R." last="Fratesi">R. Fratesi</name>
<affiliation wicri:level="1"><inist:fA14 i1="02"><s1>Dipartimento di Scienze dei Materiali e della Terra</s1>
<s2>Ancona</s2>
<s3>ITA</s3>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>Dipartimento di Scienze dei Materiali e della Terra</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Roventi, G" sort="Roventi, G" uniqKey="Roventi G" first="G." last="Roventi">G. Roventi</name>
<affiliation wicri:level="1"><inist:fA14 i1="02"><s1>Dipartimento di Scienze dei Materiali e della Terra</s1>
<s2>Ancona</s2>
<s3>ITA</s3>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>Dipartimento di Scienze dei Materiali e della Terra</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Barucca, G" sort="Barucca, G" uniqKey="Barucca G" first="G." last="Barucca">G. Barucca</name>
<affiliation wicri:level="1"><inist:fA14 i1="03"><s1>INFM Università degli Studi di Ancona, Via Brecce Bianche</s1>
<s2>60131, Ancona</s2>
<s3>ITA</s3>
<sZ>5 aut.</sZ>
</inist:fA14>
<country>Italie</country>
<wicri:noRegion>60131, Ancona</wicri:noRegion>
</affiliation>
</author>
</analytic>
<series><title level="j" type="main">Journal of applied electrochemistry</title>
<title level="j" type="abbreviated">J. appl. electrochem.</title>
<idno type="ISSN">0021-891X</idno>
<imprint><date when="1999">1999</date>
</imprint>
</series>
</biblStruct>
</sourceDesc>
<seriesStmt><title level="j" type="main">Journal of applied electrochemistry</title>
<title level="j" type="abbreviated">J. appl. electrochem.</title>
<idno type="ISSN">0021-891X</idno>
</seriesStmt>
</fileDesc>
<profileDesc><textClass><keywords scheme="KwdEn" xml:lang="en"><term>Bragg diffraction</term>
<term>Corrosion resistance</term>
<term>Electroless plating</term>
<term>Grazing incidence</term>
<term>Medium effect</term>
<term>Morphology</term>
<term>Nickel Alloys</term>
<term>Phosphorus Alloys</term>
<term>Scanning electron microscopy</term>
<term>Sulfates</term>
<term>Surface structure</term>
<term>Ternary alloy</term>
<term>Transmission electron microscopy</term>
<term>X ray diffraction</term>
<term>Zinc Alloys</term>
<term>pH</term>
</keywords>
<keywords scheme="Pascal" xml:lang="fr"><term>Résistance corrosion</term>
<term>Dépôt par oxydoréduction</term>
<term>Alliage ternaire</term>
<term>Nickel Alliage</term>
<term>Zinc Alliage</term>
<term>Phosphore Alliage</term>
<term>Sulfate</term>
<term>Effet milieu</term>
<term>pH</term>
<term>Morphologie</term>
<term>Structure surface</term>
<term>Microscopie électronique balayage</term>
<term>Diffraction RX</term>
<term>Microscopie électronique transmission</term>
<term>Diffraction Bragg</term>
<term>Incidence rasante</term>
</keywords>
</textClass>
</profileDesc>
</teiHeader>
<front><div type="abstract" xml:lang="en">Electroless Ni-Zn-P alloy coatings were obtained on an iron substrate from a sulfate bath at various pH values. The effects of changes in bath pH on alloy composition, morphology, microstructure and corrosion resistance were studied. Scanning electron microscopy was performed to observe the morphological change of the deposits with bath pH. Coating crystallinity was investigated by grazing incidence asymmetric Bragg X-ray diffraction and transmission electron microscopy. A transition from an amorphous to polycrystalline structure was observed on increasing the bath alkalinity, and thus decreasing the phosphorus content of the alloys. A single crystalline phase corresponding to face-centred-cubic nickel was identified in the alloys obtained from a strong alkaline solution. An increase in zinc percentage up to 23% in the deposits does not change the f.c.c. nickel crystalline structure. Corrosion potential and polarization resistance measurements indicated that the corrosion resistance of electroless Ni-Zn-P alloys depends strongly on the microstructure and chemical composition. The deposits obtained at pH 9.0-9.5 and with 11.4-12.5% zinc and 11.8-11.2% phosphorous exhibited the best corrosion resistance.</div>
</front>
</TEI>
<affiliations><list><country><li>Italie</li>
<li>Maroc</li>
</country>
<region><li>Rabat-Salé-Kénitra</li>
</region>
<settlement><li>Rabat</li>
</settlement>
</list>
<tree><country name="Maroc"><region name="Rabat-Salé-Kénitra"><name sortKey="Bouanani, M" sort="Bouanani, M" uniqKey="Bouanani M" first="M." last="Bouanani">M. Bouanani</name>
</region>
<name sortKey="Cherkaoui, F" sort="Cherkaoui, F" uniqKey="Cherkaoui F" first="F." last="Cherkaoui">F. Cherkaoui</name>
</country>
<country name="Italie"><noRegion><name sortKey="Fratesi, R" sort="Fratesi, R" uniqKey="Fratesi R" first="R." last="Fratesi">R. Fratesi</name>
</noRegion>
<name sortKey="Barucca, G" sort="Barucca, G" uniqKey="Barucca G" first="G." last="Barucca">G. Barucca</name>
<name sortKey="Roventi, G" sort="Roventi, G" uniqKey="Roventi G" first="G." last="Roventi">G. Roventi</name>
</country>
</tree>
</affiliations>
</record>

Pour manipuler ce document sous Unix (Dilib)

EXPLOR_STEP=$WICRI_ROOT/Wicri/Terre/explor/NickelMaghrebV1/Data/Main/Exploration

HfdSelect -h $EXPLOR_STEP/biblio.hfd -nk 000C66 | SxmlIndent | more

HfdSelect -h $EXPLOR_AREA/Data/Main/Exploration/biblio.hfd -nk 000C66 | SxmlIndent | more

Pour mettre un lien sur cette page dans le réseau Wicri

{{Explor lien
   |wiki=    Wicri/Terre
   |area=    NickelMaghrebV1
   |flux=    Main
   |étape=   Exploration
   |type=    RBID
   |clé=     Pascal:99-0360542
   |texte=   Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath
}}

This area was generated with Dilib version V0.6.27.
Data generation: Fri Mar 24 23:14:20 2017. Site generation: Tue Mar 5 17:03:47 2024

	Serveur d'exploration sur le nickel au Maghreb
	Attention, ce site est en cours de développement ! Attention, site généré par des moyens informatiques à partir de corpus bruts. Les informations ne sont donc pas validées.

Serveur d'exploration sur le nickel au Maghreb

Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath

Microstructural characterization and corrosion resistance of Ni-Zn-P alloys electrolessly deposited from a sulphate bath

Source :

Descripteurs français

English descriptors

Abstract

Links toward previous steps (curation, corpus...)

Le document en format XML

Pour manipuler ce document sous Unix (Dilib)

Pour mettre un lien sur cette page dans le réseau Wicri