Obtaining, structural and corrosion characterization of anodized nanolayers on Ti-20Zr alloy surface
Identifieur interne : 002E48 ( Main/Exploration ); précédent : 002E47; suivant : 002E49Obtaining, structural and corrosion characterization of anodized nanolayers on Ti-20Zr alloy surface
Auteurs : Jose M. Calderon Moreno [Roumanie] ; Petre Osiceanu [Roumanie] ; Cora Vasilescu [Roumanie] ; Mihai Anastasescu [Roumanie] ; Silviu Iulian Drob [Roumanie] ; Monica Popa [Roumanie]Source :
- Surface & coatings technology [ 0257-8972 ] ; 2013.
Descripteurs français
- Pascal (Inist)
- Wicri :
- topic : Corrosion.
English descriptors
- KwdEn :
Abstract
The binary Ti-20Zr alloy was elaborated with the aim to be used as small diameter implant placed in narrow edentulous ridge. The alloy surface was galvanostatically anodized in 1 M H3PO4 solution to increase its corrosion resistance and bioactivity. The results of energy dispersive X-ray spectroscopy, Raman spectroscopy, Fourier-transform infrared and X-ray photoelectron spectroscopy showed that the alloy surface was covered by a quasi-amorphous TiO2 oxide based nanolayer with very small crystalline nuclei of rutile-type structure that incorporated phosphorous ions. The anodized nanolayer revealed submicron surface features and nanoscale roughness measured by atomic force microscopy, and flake-like platelets observed by scanning electron microscopy. The electrodeposited nanolayer acted as a barrier against the diffusion of ions through it and reduced very much (about ten times lower) the corrosion and ion release rates, a good indicator of increased long-term alloy biocompatibility in Ringer's solutions/simulated body fluids. The main electrochemical parameters evinced a nobler behavior of the anodized alloy in comparison with bare one. Electrochemical impedance spectroscopy indicated that the anodization treatment provided the formation of a more stable, resistant nanolayer. Long-term experiments denoted the improvement over time of the protective properties of the anodized nanolayer by its thickening. Immersion of the anodized alloy in neutral and alkaline Ringer's solutions resulted in the deposition of nanostructured coatings with a morphology of entangled acicular n-HA nanocrystallites, while brushite coatings deposited in acid Ringer's solution. The anodized nanolayer obtained on the Ti-20Zr alloy surface endowed the substrate both with protection and bioactivity.
Affiliations:
Links toward previous steps (curation, corpus...)
- to stream PascalFrancis, to step Corpus: 000007
- to stream PascalFrancis, to step Curation: 000689
- to stream PascalFrancis, to step Checkpoint: 000013
- to stream Main, to step Merge: 002E63
- to stream Main, to step Curation: 002E48
Le document en format XML
<record><TEI><teiHeader><fileDesc><titleStmt><title xml:lang="en" level="a">Obtaining, structural and corrosion characterization of anodized nanolayers on Ti-20Zr alloy surface</title>
<author><name sortKey="Calderon Moreno, Jose M" sort="Calderon Moreno, Jose M" uniqKey="Calderon Moreno J" first="Jose M." last="Calderon Moreno">Jose M. Calderon Moreno</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Osiceanu, Petre" sort="Osiceanu, Petre" uniqKey="Osiceanu P" first="Petre" last="Osiceanu">Petre Osiceanu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Vasilescu, Cora" sort="Vasilescu, Cora" uniqKey="Vasilescu C" first="Cora" last="Vasilescu">Cora Vasilescu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Anastasescu, Mihai" sort="Anastasescu, Mihai" uniqKey="Anastasescu M" first="Mihai" last="Anastasescu">Mihai Anastasescu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Drob, Silviu Iulian" sort="Drob, Silviu Iulian" uniqKey="Drob S" first="Silviu Iulian" last="Drob">Silviu Iulian Drob</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Popa, Monica" sort="Popa, Monica" uniqKey="Popa M" first="Monica" last="Popa">Monica Popa</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
</titleStmt>
<publicationStmt><idno type="wicri:source">INIST</idno>
<idno type="inist">14-0069462</idno>
<date when="2013">2013</date>
<idno type="stanalyst">PASCAL 14-0069462 INIST</idno>
<idno type="RBID">Pascal:14-0069462</idno>
<idno type="wicri:Area/PascalFrancis/Corpus">000007</idno>
<idno type="wicri:Area/PascalFrancis/Curation">000689</idno>
<idno type="wicri:Area/PascalFrancis/Checkpoint">000013</idno>
<idno type="wicri:explorRef" wicri:stream="PascalFrancis" wicri:step="Checkpoint">000013</idno>
<idno type="wicri:doubleKey">0257-8972:2013:Calderon Moreno J:obtaining:structural:and</idno>
<idno type="wicri:Area/Main/Merge">002E63</idno>
<idno type="wicri:Area/Main/Curation">002E48</idno>
<idno type="wicri:Area/Main/Exploration">002E48</idno>
</publicationStmt>
<sourceDesc><biblStruct><analytic><title xml:lang="en" level="a">Obtaining, structural and corrosion characterization of anodized nanolayers on Ti-20Zr alloy surface</title>
<author><name sortKey="Calderon Moreno, Jose M" sort="Calderon Moreno, Jose M" uniqKey="Calderon Moreno J" first="Jose M." last="Calderon Moreno">Jose M. Calderon Moreno</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Osiceanu, Petre" sort="Osiceanu, Petre" uniqKey="Osiceanu P" first="Petre" last="Osiceanu">Petre Osiceanu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Vasilescu, Cora" sort="Vasilescu, Cora" uniqKey="Vasilescu C" first="Cora" last="Vasilescu">Cora Vasilescu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Anastasescu, Mihai" sort="Anastasescu, Mihai" uniqKey="Anastasescu M" first="Mihai" last="Anastasescu">Mihai Anastasescu</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Drob, Silviu Iulian" sort="Drob, Silviu Iulian" uniqKey="Drob S" first="Silviu Iulian" last="Drob">Silviu Iulian Drob</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
<author><name sortKey="Popa, Monica" sort="Popa, Monica" uniqKey="Popa M" first="Monica" last="Popa">Monica Popa</name>
<affiliation wicri:level="1"><inist:fA14 i1="01"><s1>Romanian Academy, Institute of Physical Chemistry "Ilie Murgulescu", Spl. Independentei 202</s1>
<s2>060021 Bucharest</s2>
<s3>ROU</s3>
<sZ>1 aut.</sZ>
<sZ>2 aut.</sZ>
<sZ>3 aut.</sZ>
<sZ>4 aut.</sZ>
<sZ>5 aut.</sZ>
<sZ>6 aut.</sZ>
</inist:fA14>
<country>Roumanie</country>
<wicri:noRegion>060021 Bucharest</wicri:noRegion>
</affiliation>
</author>
</analytic>
<series><title level="j" type="main">Surface & coatings technology</title>
<title level="j" type="abbreviated">Surf. coat. technol.</title>
<idno type="ISSN">0257-8972</idno>
<imprint><date when="2013">2013</date>
</imprint>
</series>
</biblStruct>
</sourceDesc>
<seriesStmt><title level="j" type="main">Surface & coatings technology</title>
<title level="j" type="abbreviated">Surf. coat. technol.</title>
<idno type="ISSN">0257-8972</idno>
</seriesStmt>
</fileDesc>
<profileDesc><textClass><keywords scheme="KwdEn" xml:lang="en"><term>Anodizing</term>
<term>Corrosion</term>
<term>Impedance</term>
<term>Photoelectron spectroscopy</term>
<term>Raman spectroscopy</term>
<term>Scanning electron microscopy</term>
<term>Surface treatments</term>
</keywords>
<keywords scheme="Pascal" xml:lang="fr"><term>Corrosion</term>
<term>Traitement surface</term>
<term>Anodisation</term>
<term>Spectrométrie Raman</term>
<term>Spectrométrie photoélectron</term>
<term>Microscopie électronique balayage</term>
<term>Impédance</term>
</keywords>
<keywords scheme="Wicri" type="topic" xml:lang="fr"><term>Corrosion</term>
</keywords>
</textClass>
</profileDesc>
</teiHeader>
<front><div type="abstract" xml:lang="en">The binary Ti-20Zr alloy was elaborated with the aim to be used as small diameter implant placed in narrow edentulous ridge. The alloy surface was galvanostatically anodized in 1 M H<sub>3</sub>
PO<sub>4</sub>
solution to increase its corrosion resistance and bioactivity. The results of energy dispersive X-ray spectroscopy, Raman spectroscopy, Fourier-transform infrared and X-ray photoelectron spectroscopy showed that the alloy surface was covered by a quasi-amorphous TiO<sub>2</sub>
oxide based nanolayer with very small crystalline nuclei of rutile-type structure that incorporated phosphorous ions. The anodized nanolayer revealed submicron surface features and nanoscale roughness measured by atomic force microscopy, and flake-like platelets observed by scanning electron microscopy. The electrodeposited nanolayer acted as a barrier against the diffusion of ions through it and reduced very much (about ten times lower) the corrosion and ion release rates, a good indicator of increased long-term alloy biocompatibility in Ringer's solutions/simulated body fluids. The main electrochemical parameters evinced a nobler behavior of the anodized alloy in comparison with bare one. Electrochemical impedance spectroscopy indicated that the anodization treatment provided the formation of a more stable, resistant nanolayer. Long-term experiments denoted the improvement over time of the protective properties of the anodized nanolayer by its thickening. Immersion of the anodized alloy in neutral and alkaline Ringer's solutions resulted in the deposition of nanostructured coatings with a morphology of entangled acicular n-HA nanocrystallites, while brushite coatings deposited in acid Ringer's solution. The anodized nanolayer obtained on the Ti-20Zr alloy surface endowed the substrate both with protection and bioactivity.</div>
</front>
</TEI>
<affiliations><list><country><li>Roumanie</li>
</country>
</list>
<tree><country name="Roumanie"><noRegion><name sortKey="Calderon Moreno, Jose M" sort="Calderon Moreno, Jose M" uniqKey="Calderon Moreno J" first="Jose M." last="Calderon Moreno">Jose M. Calderon Moreno</name>
</noRegion>
<name sortKey="Anastasescu, Mihai" sort="Anastasescu, Mihai" uniqKey="Anastasescu M" first="Mihai" last="Anastasescu">Mihai Anastasescu</name>
<name sortKey="Drob, Silviu Iulian" sort="Drob, Silviu Iulian" uniqKey="Drob S" first="Silviu Iulian" last="Drob">Silviu Iulian Drob</name>
<name sortKey="Osiceanu, Petre" sort="Osiceanu, Petre" uniqKey="Osiceanu P" first="Petre" last="Osiceanu">Petre Osiceanu</name>
<name sortKey="Popa, Monica" sort="Popa, Monica" uniqKey="Popa M" first="Monica" last="Popa">Monica Popa</name>
<name sortKey="Vasilescu, Cora" sort="Vasilescu, Cora" uniqKey="Vasilescu C" first="Cora" last="Vasilescu">Cora Vasilescu</name>
</country>
</tree>
</affiliations>
</record>
Pour manipuler ce document sous Unix (Dilib)
EXPLOR_STEP=$WICRI_ROOT/Wicri/Santé/explor/EdenteV2/Data/Main/Exploration
HfdSelect -h $EXPLOR_STEP/biblio.hfd -nk 002E48 | SxmlIndent | more
Ou
HfdSelect -h $EXPLOR_AREA/Data/Main/Exploration/biblio.hfd -nk 002E48 | SxmlIndent | more
Pour mettre un lien sur cette page dans le réseau Wicri
{{Explor lien |wiki= Wicri/Santé |area= EdenteV2 |flux= Main |étape= Exploration |type= RBID |clé= Pascal:14-0069462 |texte= Obtaining, structural and corrosion characterization of anodized nanolayers on Ti-20Zr alloy surface }}
This area was generated with Dilib version V0.6.32. |